Influence of the ionic strength on the physicochemical properties of methotrexate-loaded chitosan polyelectrolyte complexes

Abstract Polyelectrolyte complexes (PECs) as drug delivery systems are widely explored since they are easily obtained by coacervation and biopolymers can be associated. However, particle distribution is a challenging critical parameter that has been infrequently focused. This work evaluated the effect of NaCl concentration on the physicochemical properties of PECs based on chitosan and hypromellose loaded with methotrexate. The particle size, zeta potential and polydispersity index (PdI) were determined by DLS, besides of drug entrapment efficiency (EE) and in vitro drug release profile determination. Particle size decreased while NaCl concentration rised, achieving a narrower size distribution of (345±79 nm) and PdI (0.285±0.067) with 200 mmol/L NaCl. The higher the NaCl concentration, the lower the zeta potential at acid pH. The EE was kept similar ((28.2±4.5) %) from 0 to 300 mmol/L NaCl, while 400 mmol/L NaCl impaired the drug entrapment. The addition of (200 and 300) mmol/L NaCl did not affect the drug release profile, but it was faster with (100 or 400) mmol/L. In conclusion, the addition of 200 mmol/L NaCl reduced particle size and PdI with no changes in the EE and drug release. Therefore, the ionic strength plays an important role on PECs development.

Evaluation of polyelectrolyte and emulsion covalent crosslink of chitosan for producing mesalasine loaded submicron particles

This study evaluates various techniques for producing mesalamine (5ASA)-loaded particles employing chitosan as a biopolymer: (1) the polyelectrolyte complexation of chitosan with phthalate hypromelose (HP), (2) the chemical crosslinking of chitosan with genipin and (3) the water-in-oil emulsion method associated with chemical crosslinking with genipin. Systems were characterized by dynamic light scattering, zeta potential (ζ), powder X-ray diffraction (PXRD), Fourier transform infrared spectroscopy (FTIR) and a drug release profile. Method (1) was efficiently produced unloaded nanoparticles (491 nm, PdI=0.26 and ζ = 23.2), but the conditions for chitosan and HP cross-linking enhanced the precipitation of 5ASA. Method (2) caused the degradation of the drug. Method 3 produced sub-micron and microparticles, thereby varying the agitation method; 3 h magnetic agitation resulted in 2692 nm, Pdi = 0.6 and ζ = 46, while Ultra-Turrax, 5 min produced submicron particles (537 nm, PdI = 0.6). The percentage yield was approximately 50%, which is very satisfactory considering the impossibility of encapsulating 5ASA using other methods. FTIR showed the covalent interaction of chitosan and genipin. The drug release was rapid in acidic fluid, but in neutral pH a slower release was obtained in the initial stage, followed by rapid release, which may ensure the controlled release of 5ASA in the colon.

Evaluation of skin absorption of drugs from topical and transdermal formulations

ABSTRACT The skin barrier function has been attributed to the stratum corneum and represents a major challenge in clinical practice pertaining to cutaneous administration of drugs. Despite this, a large number of bioactive compounds have been successfully administered via cutaneous administration because of advances in the design of topical and transdermal formulations. In vitro and in vivo evaluations of these novel drug delivery systems are necessary to characterize their quality and efficacy. This review covers the most well-known methods for assessing the cutaneous absorption of drugs as an auxiliary tool for pharmaceutical formulation scientists in the design of drug delivery systems. In vitro methods as skin permeation assays using Franz-type diffusion cells, cutaneous retention and tape-stripping methods to study the cutaneous penetration of drugs, and in vivo evaluations as pre-clinical pharmacokinetic studies in animal models are discussed. Alternative approaches to cutaneous microdialysis are also covered. Recent advances in research on skin absorption of drugs and the effect of skin absorption enhancers, as investigated using confocal laser scanning microscopy, Raman confocal microscopy, and attenuated total reflectance Fourier-transform infrared spectroscopy, are reviewed.

In vitro evaluation of transdermal nicotine delivery systems commercially available in Brazil

The aim of this study was to develop and validate a method for evaluating the release and skin permeation from transdermal nicotine patches using the vertical diffusion cell (VDC). The VDC is an experimental apparatus employed in research, development, and the pharmaceutical field because it can simulate conditions closest to those established in clinical trials. Two transdermal nicotine delivery systems marketed in Brazil to release 14 mg over 24 hours were evaluated. Release studies were carried out using a regenerated cellulose dialysis membrane and permeation studies were carried out using excised porcine ear skin. The results indicated that nicotine release from both evaluated patches follows Higuchi's release kinetics, while skin permeation studies indicated zero-order release kinetics. Nicotine release rates were different between both evaluated patches, but drug permeation rates were not significantly different. According to validation studies, the method was appropriate for evaluating in vitro performance of nicotine patches. The proposed method can be applied to in vitro comparative studies between different commercial nicotine patches and may be used as an auxiliary tool in the design of new transdermal nicotine delivery systems.

O objetivo deste trabalho foi o desenvolvimento e a validação de metodologia empregando a célula de difusão vertical para avaliação da liberação e permeação cutânea in vitro de nicotina a partir de adesivos transdérmicos. A célula de difusão vertical é considerada um aparato experimental importante em pesquisa e desenvolvimento e pode simular condições in vitro próximas aquelas observadas em ensaios clínicos. Neste trabalho foram avaliados dois dispositivos transdérmicos comercializados no Brasil para liberação controlada de 14 mg de nicotina em um período de 24 horas. Realizaram-se ensaios de liberação, usando membranas de diálise de celulose regenerada, e estudos de permeação cutânea, usando pele de orelha de porcos. Os resultados indicaram que a liberação da nicotina em ambos os dispositivos transdérmicos avaliados seguiu a cinética de Higuchi, enquanto que a permeação cutânea seguiu cinética de ordem zero. As velocidades de liberação foram diferentes para os dispositivos comerciais avaliados, entretanto não foram encontradas diferenças significativas para as velocidades de permeação cutânea. Conforme os estudos de validação, a metodologia mostrou-se apropriada para a avaliação in vitro da liberação e permeação cutânea a partir de adesivos transdérmicos de nicotina. O método proposto foi aplicado em estudos comparativos in vitro entre adesivos transdérmicos comerciais contendo nicotina. Deste modo, o método também pôde ser considerado como ferramenta útil que poderia ser aplicada durante o desenvolvimento de novas formulações transdérmicas para liberação de nicotina.

Comparative study of analytical methods by direct and first-derivative UV spectrophotometry for evaluation of losartan potassium in capsules / Estudo comparativo de métodos analíticos por espectrometria de UV directa e derivada de primeira ordem para a avaliação de losartano potássico em cápsulas

Losartan potassium is an antihypertensive non-peptide agent, which exerts its action by specific blockade of angiotensin II receptors. The aim of the present study was the validation and application of analytical methods for the quality control of losartan potassium 50 mg in pharmaceutical capsules, using direct and first-derivative UV spectrophotometry. Based on losartan potassium spectrophotometric characteristics, a signal at 205 nm of the zero-order spectrum and a signal at 234 nm of the first-derivative spectrum, were found adequate for quantification. The results were used to compare these instrumental techniques. The linearity between the signals and concentrations of losartan potassium in the ranges of 3.0-7.0 mg L-1 and 6.0-14.0 mg L-1 for direct and first-derivative spectrophotometry in aqueous solutions, respectively, presented a correlation coefficient (r) of 0.9999 in both cases. The methods were applied for losartan potassium in capsule dosage obtained from local pharmacies, and were shown to be efficient, easy to apply and low cost. These methods do not use polluting reagents and require relatively inexpensive equipment.

O losartano potássico é um agente anti-hipertensivo não peptídico, que exerce sua ação por bloqueio específico dos receptores da angiotensina II. Este trabalho propôs a validação e aplicação de métodos analíticos orientados ao controle de qualidade de losartano potássico 50 mg na forma farmacêutica cápsula, utilizando a espectrofotometria direta e derivada de primeira ordem na região do UV. Baseado nas características espectrofotométricas de losartano potássico, um sinal a 205 nm do espectro de ordem zero e um sinal a 234 nm do espectro de primeira derivada foram adequados para a quantificação. Os resultados foram usados para comparar essas duas técnicas instrumentais. O coeficiente de correlação entre as respostas e as concentrações de losartano potássico na faixa de 3,0-7,0 mg L-1 e 6,0-14,0 mg L-1 para espectrofotometria direta e derivada de primeira ordem em solução aquosa, respectivamente, foi de (r) of 0,9999 para ambos os casos. Os métodos foram aplicados para quantificação de losartano potássico em cápsulas obtidas de farmácias de manipulação locais e demonstraram ser eficientes, fáceis de aplicar e de baixo custo. Além disso, não necesitam de reagentes poluentes e requerem equipamentos economicamente viáveis.